Disco rear quarter light seals

John Roche · May 23, 2008

Have just discovered the dreaded leaking quarter light seals,

and the rear floor rot. The new quarter light seals are really expensive, would anyone know a reasonable source for these, plus any fitiing tips from anyone who has done this job would be much appreciated.

{Disco 5 Door}

thebiglad · May 23, 2008

John Roche said:
Have just discovered the dreaded leaking quarter light seals, and the rear floor rot. The new quarter light seals are really expensive, would anyone know a reasonable source for these, plus any fitiing tips from anyone who has done this job would be much appreciated.

{Disco 5 Door}

The seals on my wifes Disco were leaking and caused the floor to rot out completely.

After fitting a new floor I didn't want this to happen again, so I successfully sealed the existing rubbers with a bead of silicone between the rubber seal and the bodywork, then another bead between the seal and the glass.

Hasn't leaked since - hurrah !!

John Roche · May 23, 2008

Thanks Biglad,

I may have to go with the silicone option, although the old seals do have some very large splits in them, around the areas where they bend to form the corner angles.

The Mad Hat Man · May 23, 2008

i think yu can get some stuff from halfrauds to "plump up" yo old rubbers

!

thebiglad · May 23, 2008

The Mad Hat Man said:
i think yu can get some stuff from halfrauds to "plump up" yo old rubbers !

That sound disgusting, especially when they're only a couple of quid for a packet of 3

thebiglad · May 23, 2008

John Roche said:
Thanks Biglad,

I may have to go with the silicone option, although the old seals do have some very large splits in them, around the areas where they bend to form the corner angles.

I found using the black stuff that's sold for guttering repairs worked very well.

Also where the rubbers have cracked, it you first put some good quality Gaffa tape over them, you can stuff in enough mastic so that when you peel off the tape, the gaps are filled in.

Just my two penneth

Dave

discool · May 23, 2008

I don't have the problem, yet, but i may have a look at this stuff also.
http://www.captaintolley.com/
It was recommended in this forun a short while ago.

John Roche · May 23, 2008

Thanks for info, there is a stockist listed in Southampton which is quite close to me, sounds like the easiest solution.

Best Regards
John

Disco rear quarter light seals

John Roche

New Member

thebiglad

Well-Known Member

John Roche

New Member

The Mad Hat Man

Well-Known Member

thebiglad

Well-Known Member

thebiglad

Well-Known Member

discool

Well-Known Member

John Roche

New Member

Similar threads