td4 smoking

bandit600 · Mar 27, 2009

hello
a little advice needed again

i have a td4 on a 02 plate 150, 000 with fsh
it has trouble starting in the morns, starts then cuts out after a few goes she start but needs a bit af revvin, loads of smoke which i put down to unused fuel
then she started to lack power at junctions

which is a bit of a worry, i unplugged the maf which seemed ti help with the power loss a bit but now she blows smoke on starting, then clears then when driving she'll smoke for 5 mins then stop then start again, this goes on all the time, when she smokes whilst driving she seems to lose power and judders very gently

any idea's where to start

cheers

Dann · Mar 28, 2009

What colour is the smoke?

Black: Shortage of air- check turbo pipes carefully to start with.
White: Poor combustion producing unburnt diesel in the exhaust.

bandit600 · Mar 28, 2009

Dann said:
What colour is the smoke?

Black: Shortage of air- check turbo pipes carefully to start with.
White: Poor combustion producing unburnt diesel in the exhaust.

hello

it seems white/grey, i'm not losing oil so dont think its that and even thought bad fuel but had several tanks full now

what would cause over fuel??? would it come and go??

cheers

caravan doctor · Mar 28, 2009

when was the last time your diesal filter was changed????

bandit600 · Mar 28, 2009

caravan doctor said:
when was the last time your diesal filter was changed????

i would assume on last one , only had it 3 months and was serviced just before, might change it if that may be the problem

cheers

Dann · Mar 28, 2009

A new fuel filter is always a good idea when first buying a TD4 as they tend to get ignored during services because they are a bit awkward to change.

Check the electrical connections for signs of corrosion/looseness on the two fuel pressure sensors:

Low pressure- Has a three wire plug and located on the fuel filter housing.

High pressure- Screwed into the end of the fuel rail nearest battery.

chromiumuk · Mar 30, 2009

Also change the crankcase breather filter/valve assembly.
Bang in plenty of Millers Powersport 4 diesel additive at least double dose.

Also you mention disconnecting your MAF. I take it you've now either fitted a new one, or one of Roverrons Mafam compensators & aren't just running around with it disconnected.

bandit600 · Mar 31, 2009

last 2 days seems to be running better, re fitted the maf, going to give it another full service the weekend anyway just to be sure and see if it stays ok
or as arnie says i'll be back :doh:

Optimus Prime · Apr 1, 2009

had similar, turned out to be a failed injector letting pressure leak off on starting.

td4 smoking

bandit600

New Member

Dann

Active Member

bandit600

New Member

caravan doctor

New Member

bandit600

New Member

Dann

Active Member

chromiumuk

Well-Known Member

bandit600

New Member

Optimus Prime

Well-Known Member

Similar threads