starting problems

si844 · Jan 15, 2009

recently i have been having problems starting my car (disco 200tdi). it turns over for up to 10 seconds before starting then has a slight misfire and a cloud of smoke for a min, then it'l be fine for a couple of days.

any ideas wot it could be?

Paul D · Jan 15, 2009

Injector leak-off pipes cracked/split would be first guess, check glow plugs work, change fuel filter/sedimenter clean-up.

si844 · Jan 15, 2009

i'l check the pipes, i'v never needed to wait for glow plugs even wen below freezing, fuel filter and sedimeter was done couple thousand miles ago

leekegs · Jan 15, 2009

si844 said:
i'l check the pipes, i'v never needed to wait for glow plugs even wen below freezing, fuel filter and sedimeter was done couple thousand miles ago

Hello
youre right a good 200tdi doesn't need to use glow plugs check the flow/return pipes on top of your tank under the boot floor these little ****s rust and get small pin holes which pull in air causing your symptoms if they are good grease them up so they wont cause hassle down the line it may also be worth checking the cut off solenoid on injector pump they stick especially if you have used veg oil

leekegs

si844 · Jan 15, 2009

leekegs said:
Hello
youre right a good 200tdi doesn't need to use glow plugs check the flow/return pipes on top of your tank under the boot floor these little ****s rust and get small pin holes which pull in air causing your symptoms if they are good grease them up so they wont cause hassle down the line it may also be worth checking the cut off solenoid on injector pump they stick especially if you have used veg oil
leekegs

ok i will check them too over the weekend. do u check these pipes from under the car?

ye have used veg in past. dunno wot the solenoid looks like tho. where on the pump is it?

cheers

leekegs · Jan 15, 2009

hello

to check the flow/return pipes lift up boot carpet and sound proofing and the inspection plate is in the centre near the back. The solenoid is at the back of the pump with a wire coming off it ( also makes a cheap imobilser if you remove wire car wont start) it is easy to remove and clean/replace if defective they are very cheap hope this helps.

my solenoid kept sticking open so car ran with keys out of ignition amusing but annoying removed and cleaned and now works fine yours could be doing opposite if you have no luck with these the lift pump could on its way out

hope this helps

leekegs

si844 · Jan 19, 2009

car seems a lot better now. seems like its been using oil and now i'v added 3.5 liters its much better.

starting problems

si844

New Member

Paul D

Old, nackered 'n broke, but the Landy is fine . :)

si844

New Member

leekegs

New Member

si844

New Member

leekegs

New Member

si844

New Member

Similar threads