Done everything but still nothing

This site contains affiliate links for which LandyZone may be compensated if you make a purchase.
S

skippy22

New Member
Posts
170
Location
bedfordshire
here goes i have done the following
1. glow plugs
2. glow plug relay
3. engine heat temperature sensor
4. leak off pipes
5. one way stop valve
right ive done all above but still take a fair bit of turning over to start (warm or cold), the glow plug light only stays on for about 5 seconds everytime i was told thats not long enough thats why i done heat temp sensor, has anyone else got a clue please say you have this cars doing my nut in now :mad:
 
skippy22 said:
here goes i have done the following
1. glow plugs
2. glow plug relay
3. engine heat temperature sensor
4. leak off pipes
5. one way stop valve
right ive done all above but still take a fair bit of turning over to start (warm or cold), the glow plug light only stays on for about 5 seconds everytime i was told thats not long enough thats why i done heat temp sensor, has anyone else got a clue please say you have this cars doing my nut in now :mad:
Click to expand...

You could try wiring up a relay fed direct from the battery and manual control switch to operate the glowplugs, leave them on for 30 seconds and try to start it, but seeing as you say it's just as bad hot, I reckon the fault lies elswhere.
Maybe the fuel cut of solenoid in the injector pump?:eek:
 
Datatek said:
You could try wiring up a relay fed direct from the battery and manual control switch to operate the glowplugs, leave them on for 30 seconds and try to start it, but seeing as you say it's just as bad hot, I reckon the fault lies elswhere.
Maybe the fuel cut of solenoid in the injector pump?:eek:
Click to expand...


oh yeah i have done the fuel cut off solinoid aswell, it has the hot start problem but ill bet that sorted when i got glow plug problem sorted
 
Have you checked you're getting fuel when you're cranking? Does the fuel pump work? Is the air filter clogged? Are the air inlet pipes on, sealed and not split or perished? Is there a good earth between the engine casing and chassis and chassis to battery? You say you have a new battery on, but did you check the other end of the battery connection for soundness and cleanliness? Have you changed the fuel filter? Have you got fuel in the tank? Have you bled/purged the fuel system?

You say it takes a fair bit of tuening over ... does this mean the engine turns over slowly, or takes many revolutions to fire, or both? If it's turning slowly remove glow plugs and turn it again to see if the cranking speed increases. Could be a poor starter motor.
It could be that it just needs a damn good service and a bit of TLC on the injector pump side .. try asking a specialist diesel place rather than a Landrover place ;)
 
skippy22 said:
ever since i had it its been like it, its a very good battery i only brought it off ebay few weeks ago its a 670cca
LUCAS 12V 643/644 HEAVY DUTY LORRY/TRUCK BATTERY on eBay (end time 17-Aug-09 16:00:10 BST)
Click to expand...


The Range Rover Manual states a battery with a 107 amp/hour rating is required for the diesel.

When I first purchased my diesel it was slow to start hot or cold, then I changed the battery to a 1000cca spec, the difference is amazing, it now starts almost immmedatly hot or cold compared to when I purchased it.

Please note: The link above was not the supplier of the battery I fitted to my vehicle, but I may have a spare new 1000 cca battery available, if anyone require a decent battery.........
 
Last edited:
zzr1200 said:
The Range Rover Manual state a battery with a 107 amp/hour rating is required for the diesel.

When I first purchased my diesel it was slow to start hot or cold, then I changed the battery to a 1000cca spec, the difference is amazing, it now starts almost immmedatly hot or cold compared to when I purchased it.
Click to expand...

Thats a very good point, if the cranking speed is too slow starting will be difficult. Just had the same problem on my tractor, turned out to be the bearings shot in the starter motor:eek: Fitted new starter motor and it cranked twice as fast and now starts instantly:D
 
zzr1200 said:
The Range Rover Manual states a battery with a 107 amp/hour rating is required for the diesel.

When I first purchased my diesel it was slow to start hot or cold, then I changed the battery to a 1000cca spec, the difference is amazing, it now starts almost immmedatly hot or cold compared to when I purchased it.

Please note: The link above was not the supplier of the battery I fitted to my vehicle, but I may have a spare new 1000 cca battery available, if anyone require a decent battery.........
Click to expand...


how much for your battery, i was given the link i listed by few people on this forum who said its good for dse's
 
Paul D said:
Have you checked you're getting fuel when you're cranking? Does the fuel pump work? Is the air filter clogged? Are the air inlet pipes on, sealed and not split or perished? Is there a good earth between the engine casing and chassis and chassis to battery? You say you have a new battery on, but did you check the other end of the battery connection for soundness and cleanliness? Have you changed the fuel filter? Have you got fuel in the tank? Have you bled/purged the fuel system?

You say it takes a fair bit of tuening over ... does this mean the engine turns over slowly, or takes many revolutions to fire, or both? If it's turning slowly remove glow plugs and turn it again to see if the cranking speed increases. Could be a poor starter motor.
It could be that it just needs a damn good service and a bit of TLC on the injector pump side .. try asking a specialist diesel place rather than a Landrover place ;)
Click to expand...



seems to be turning over fine just to many turns
 
Sorry for so many quotes was easier replying that way,
but still seems like glow plugs or something to me, everyone says in mornings they should be on for 20-30 secs but mine are 5 seconds EVERY time
 
big dave2 said:
SORRY TO HERE @ YOUR BAD STARTING MY 96 DSE 5 SECS ON THE HEPLUGS BIT CRANK AND AWAY SHE GOES . BOUGHT HER END OF MAY COS FAMILY WERE CHUNTERING @ ALL THE OLD JUNK I USUALLY DRIVE HOPE THIS HELPS ARE U SURE all THE PLUGS R WORKING? BEST OF LUCK MATE
Click to expand...

i checked last week all were between 11 and 11.50,
i have a 7.5t recovery truck ill check see if that has a better battery if so ill swap it over and try that
 
You must log in or register to reply here.

Similar threads

Atomician
FL1 bad start
Replies
3
Views
832
Alteredtech
Alteredtech
J
P38 2.5 dhse - strange starting issue only every 3 starts
2
Replies
27
Views
3K
Grrrrrr
Grrrrrr
MikeFl4
P38A M51 Diesel - Lumpy idle after rev - Setting the top section of the pump?
Replies
4
Views
1K
Datatek
Datatek
Gunter Shingleditch
Freelander 1 TD4 puff of smoke on start-up, stinky exhaust and shudders at 1000 RPM - SOLVED
Replies
15
Views
2K
kernowsvenski
kernowsvenski
MikeFl4
P38A M51 Diesel – Its just not running right!! (video explanation for ease)
Replies
15
Views
2K
Datatek
Datatek
Back
Top