Search results

I have an X-brake, it's brilliant. I put off getting one for ages because of the expense and my determination to stick with the original drum brake. I have an occasional drip of oil from the gearbox output, even after new bearing and seal eventually it collected in the drum and contaminated the...

Hi I've had this happen twice, 1st time was master switch on steering column - easy to replace. 2nd time it happened I replaced the master switch but didn't fix it. I eventually traced it to the dim dip system. It's easy enough to by-pass the dim dip system. If I remember right, there are only...

a warped disk could also give extra pedal travel

Hi, my 300tdi was the same for a long time, I eventually discovered that the pistons in the calipers were corroded and so not operating evenly, it is possible to replace just the pistons and seals and clean up the calipers but mine were so bad I decided to change all the calipers and pistons. It...

I probably went a bit over the top. As I had a few suspect earths I ran another large diameter cable from the battery to the engine and chassis and then to a point on the bulkhead to which I have attached the radio and any components with questionable earths. The biggest culprit seemed to be a...

This happened to my 300tdi. It was bad earthing. I added a separate earth to the radio and it was fine. The previously installed spot lights and radio were earthed in the same spot and the initial surge of the spots was enough to upset the radio.

Hi. I bought my defender 300tdi 110 from Liveridges about 4 years ago. I specifically wanted a 200 or 300tdi and looked for ages to try and find something I could use as my daily driver. Until you start looking for something decent you don't realise how hard it is to find something. Liveridges...

Thanks for reply buster. I suppose it did cross my mind that oil could also contaminate the X-Eng pads also, but I thought perhaps cause the pads were postioned slightly differently and unable to "collect" oil so that the problem may not occur as it does in the drum brake. I know it seems a bit...

Hi, the handbrake on my 300tdi is rubbish. I think it is mainly due to the odd drip of oil from the transfer box eventually building up and ruining the pads. I even changed the output flange and seals on the transfer box but it didn't take long for the problem to return and I'm fed up with...

Hi After several years of mixing new veg oil with diesel at no more than about 30% when I can find it cheap enough to make it worth while in my 300tdi, I was intrigued to read that some people are mixing used engine oil with their diesel - so as I had a fair bit of used oil and a lot of odds and...

Hi I've had a few similar problems with light failures, on one occasion it was the dim-dip relay which is easy enough to remove totally, but your problem sounds more like the master light switch.

Hi The switch seems to be the most likely cause, so I shall try a new one tomo regardless. I am no expert but I have run a feed direct from the output of the switch to the dipped beam feed from the fuse box and both outputs from the switch (red and blue cables) and they both operate the dipped...

Hi I have a 1997 300tdi Defender, tonight I have completely lost dipped beam, but I still retain side lights and full beam. Several years ago I had a similar problem which turned out to be the master light switch on the columnn, However after taking the switch off tonight the switch seems to be...

Thanks for your replies - much appreciated !

Hi, I have had my home heating changed from oil to gas and I am going to have to pay to have the remaining oil removed from my tank before I can get the tank moved. I already run a small percentage of veg oil in my 300tdi - would it hurt to add a small amount of central heating oil or does...

I stuck some self adhesive sound deading underneath my bonnet and it did indeed make a difference. I think it is worth buying reasonable quality stuff, I used a company off ebay selling sommat called "edead" I think. I had enough to cover the inside of the bonnet twice and put the rest on my...

Hi, I recently took the EGR system off my 300tdi. The box located in the battery compartment can simply be unplugged and removed. It makes a much tidier job if you remove your EGR from the manifold totally rahter than just inserting the blanking, and then blank off the vacumm hoses on the air...

I have a 300tdi which was exactly the same. By disconnecting this box your EGR system should be made inoperable. The exhaust gas recirculation device is only fitted to reduce emissions in certain conditions but is not required in the UK, popular opinion seems to think it's best to disconnect the...

what's a "spider thingy" ?

Hi, I have a 1997 110 300tdi, ocassionally when I go to start it, I get ignition lights but nothing else, I've just removed an aftermarket immobilzer just in case and was wondering if there is a starter relay that's easy to change before I go down the starter motor route ? Thanks