No gears

This site contains affiliate links for which LandyZone may be compensated if you make a purchase.
D

DISCOGUY

New Member
Posts
27
HELP!!
I have a 1990 200TDI Disco1 that has lost all drive? I was pulling away from a junction in 1st when it felt like she'd slipped out of gear. Clutch operation is normal, gear lever operation is normal and diff-lock/high-low lever is operating normally. There are no strange noises.
My usual mechanic thinks it's the transfer-box.
I am looking for a second-hand one. Can anyone tell me which boxes will fit? 300TDI or Range Rover classic? Or does it have to be a 200TDI?
Do you think it's the transfer-box?
Any advice gratefully received.
Regards, Guy.
 
Is cover on a side, on top or underneath? Will I be able to see or feel if splines are shot? If it is the shaft, can I replace just that?
 
The cover is at the rear of the t/box, just up from the handbrake drum, remove it then you can see the transfer gear, you check to see if the shaft is turning inside the gear.
If it is you need to fit a new output shaft to the gearbox, plus a new transfer gear, unless you can do it yourself it's cheaper to fit another box .
 
indeed dependant on where you are located there is people with disco boxes kicking about as its quite a common problem.
 
well i'm miles away in Bedfordshire so your better off grabing one more local and tbh my gearbox has some spline wear hence why its very cheap and only really good for somone to get them out the crap for a while so they can save for a recon unit.
 
You must log in or register to reply here.

Similar threads

JoeCoutz
TD5 90 2006, loss of drive. No gears work.
Replies
4
Views
485
Spudgun!
S
Moorhouse2
Series 3 Gearshift Jammed in Neutral on S3
Replies
15
Views
1K
tottot
tottot
G
Land Rover 300tdi clutch not disengaging after engine out
Replies
8
Views
2K
miktdish
miktdish
P
L322 TD6 lost all drive
Replies
5
Views
279
backinblack
backinblack
H
Transfer box failure
2
Replies
32
Views
7K
Hector the Bad
H
Back
Top